Rolling ladders and stairways are found in many warehouses, retail outlets and storage
facilities. Drivers of trucks also use rolling ladders in fire stations and truck stops to clean
windshields and service the tops of their trucks. Rolling ladders are made of lightweight
tubular steel that is welded to large steps, usually made of expanded steel treads. Rolling
ladders vary in height from short, two-step models to tall, twelve foot models. Review
these safety tips:
BACKGROUND
Each year , accidents involving ladders cause an estimated 300 deaths and 130,000 injuries
requiring emergency medical attention.
LADDER ACCIDENTS
Ladder accidents usually are caused by improper selection, care or use, not by manufacturing defects.
Some of the more common hazards involving ladders, such as instability, electrical shock, and falls,
can be predicted and prevented. Prevention requires proper planning, correct ladder
selection, good work procedures and adequate ladder maintenance.
Click to watch a video : https://www.youtube.com/watch?v=nCNiNmP2l2I
LADDER SAFETY BASICS
Survey the area for overhead power lines before
setting up and climbing ladders.
Inspect ladders before climbing.
Never use a damaged or unsafe ladder.
Verify ladder capacity before climbing.
Don’t use them for anything other than the job
they’re intended to do.
Never stand on the top two steps of a stepladder,
and don’t use a step ladder as a straight ladder.
Raise extension ladders 3 feet (3 or 4 rungs) over the
landing area.
Tie off / secure extension ladders to prevent tip over
or kick out.
ROLLING LADDER SAFETY
Keep rolling ladders in good mechanical condition.
Rolling ladders that are stored outside should be protected from rain, snow and ice.
Rolling ladders that are stored outside should be inspected regularly for rust and corrosion.
Inspect rolling ladders before use.
Rolling ladders that have been damaged or “sprung” must be removed from service.
Rolling ladders that have missing rubber “feet” should have them replaced.
Rolling ladders should be climbed facing the ladder – not facing outward.
Climb rolling ladders using 3-point contact – do not carry loads that are too bulky or heavy.
Do not over reach – could cause ladder to tip.
Do not stand on the hand rails.
Do not move an occupied ladder.
Never stand with one foot on the ladder and the other on an object such as shelving.
Do not set up rolling ladders in areas where doors could swing open into the ladder.
Avoid setting up rolling ladders in direct proximity to forklift or vehicle traffic.
Do not tamper with or modify ladders.
Remove tools, equipment or boxes before moving a rolling ladder.
Use the step brake / lock if equipped.
Consider tying off / securing the rolling ladder if tipping is a concern.
Do not attempt to gain additional height by standing on boxes or buckets atop rolling ladder platforms.
Submit ladder maintenance requests / safety concerns in writing.
Click to watch a video : https://www.youtube.com/watch?v=H-2eEdyIGR0
Join ASHEI… Be a certified Safety Professional.
Registration going on for May batch. Few seats available.
NEBOSH, IOSH, IADC RIGPASS, OSH DIPLOMA, CIEH, OHSAS, BSE LEVEL 6 etc…
RESERVE YOUR SEAT AND BECOME A SAFETY PROFESSIONAL….
ASHEI
An ISO 9001:2008 Certified – Environment Health and Safety Training Institute
IOSH|NEBOSH|CIEH|IADC Rigpass Accredited center @ Kochi
First Floor, Suprans Arcade, Aishwarya Road,
Opposite to Kaloor International Stadium,
Palarivattom(PO), Ernakulam – 682 025
Phone : 0091 484 2343590
Mob : 91 85 928593 85 , 9447609617
Web:-www.asheinstitute.com
WhatsApp us